04 treg, powertrain data bus defective

A

alphaseinor

TDI Innovator, Gone but Not Forgotten
Joined
Jul 30, 2006
Location
Denton, TX
TDI
'03 Jetta TDI 780,000 miles (totaled out), 01 Audi TT 225 Quattro 230,000 Miles (runs great!), 00 Cabreetle Beetle dash, ALH & MK4 harness Swap
Strange things are afoot at the circle k this month!

Okay, so we get a ton of faults in the system if I floor it, or have any load on the system... it basically limp modes everything and you get to reset and drive happy to keep it from shutting down again.

Just trying to put it out there to see if anyone else has seen this before


-------------------------------------------------------------------------

Wednesday,01,August,2012,21:32:39:58451
VCDS Version: Release 11.11.3 (x64)
Data version: 20120401
Digi Sport Performance 110A Rose Lane, Suite 104, Frisco, TX 75034



--------------------------------------------------------------------------------
--------------------------------------------------------------------------------


Chassis Type: 7L - VW Touareg
Scan: 01 02 03 05 06 08 09 11 13 15 16 17 18 19 1C 22 29 32 34 36
37 39 3C 46 47 55 56 57 64 65 68 69 6C 6D 6E 75 76 77

VIN: WVGHH77L84D062163 Mileage: 215450km/133874miles
-------------------------------------------------------------------------------
Address 01: Engine Labels: None
Part No SW: 070 997 016 R HW: 028 101 172 9
Component: V10 5,0L EDCG000AGMª2813
Revision: 5KO3 Serial number: VWZ3Z0D7159681
Coding: 0060575
Shop #: WSC 06526 444 84896
VCID: 2952456483E2031

3 Faults Found:
18056 - Powertrain Data Bus
P1648 - 000 - Failure - Intermittent
Freeze Frame:
RPM: 1659 /min
Torque: 118.5 Nm
Speed: 70.2 km/h
Load: 60.0 %
Voltage: 13.53 V
Bin. Bits: 00001000
(no units): 1.0

18060 - Please check DTC Memory of Transmission Controller
P1652 - 000 -
Freeze Frame:
RPM: 2604 /min
Torque: 387.1 Nm
Speed: 39.3 km/h

18253 - Please check DTC Memory of Steering Electronics (J527)
P1845 - 000 -
Freeze Frame:
RPM: 630 /min
Torque: 79.0 Nm
Speed: 0.0 km/h
Load: 0.0 %
Voltage: 11.32 V
Bin. Bits: 00001100
Bin. Bits: 00001100

Readiness: 0 1 0 0 0

-------------------------------------------------------------------------------
Address 02: Auto Trans Labels: 09D-927-750.lbl
Part No: 09D 927 750 BB
Component: AL 600 6Q 0467
Coding: 0004153
Shop #: WSC 31414 000 00000
VCID: 6FE66B7C7D862D1

1 Fault Found:
01312 - Powertrain Data Bus
014 - Defective - MIL ON

-------------------------------------------------------------------------------
Address 03: ABS Brakes Labels: 7L0-907-379-MK25.lbl
Part No: 7L0 907 379 D
Component: ESP ALLRAD MK25 0108
Coding: 0022785
Shop #: WSC 31414 000 00000
VCID: 3A708A287644B89

7 Faults Found:
01312 - Powertrain Data Bus
014 - Defective - Intermittent
00778 - Steering Angle Sensor (G85)
004 - No Signal/Communication
01314 - Engine Control Module
013 - Check DTC Memory
01315 - Transmission Control Module
004 - No Signal/Communication
02053 - Control Module for Transfer Case (J646)
004 - No Signal/Communication
02054 - Control Module for Differential Locks (J647)
013 - Check DTC Memory
01314 - Engine Control Module
004 - No Signal/Communication

-------------------------------------------------------------------------------
Address 05: Acc/Start Auth. Labels: 3D0-909-13x-05.lbl
Part No SW: 3D0 909 135 M HW: 5WK 470 26
Component: Kessy 6400
Coding: 0131304
Shop #: WSC 31414 000 00000
VCID: 2F66AB7CBD066D1

Part No: XXXXXXXXXXX
Component: ELV XXXX

6 Faults Found:
00179 - Access/Start Authorization Antenna; Drivers Side (R134)
011 - Open Circuit
00180 - Access/Start Authorization Antenna; Passenger Side (R135)
011 - Open Circuit
00181 - Access/Start Authorization Antenna (in Rear bumper) (R136)
011 - Open Circuit
01312 - Powertrain Data Bus
014 - Defective - Intermittent
00668 - Supply Voltage Terminal 30
009 - Open or Short to Ground - Intermittent
00087 - Terminal 30 for Starting Relevant Consumers
009 - Open or Short to Ground - Intermittent

-------------------------------------------------------------------------------
Address 06: Seat Mem. Pass Labels: None
Part No: 7L0 959 760
Component: Sitzverstellung 0701
Shop #: WSC 00000 000 00000
VCID: F7F6D31C85D6E51

No fault code found.

-------------------------------------------------------------------------------
Address 08: Auto HVAC Labels: 7L6-907-040.clb
Part No: 7L6 907 040 H
Component: CLIMAtronic R/L X 3716
Coding: 0000030
Shop #: WSC 31414 000 00000
VCID: 356A99145F5A571

Part No: 7L6 907 040 H
Component: CLIMAtronic R/L X 3716

3 Faults Found:
02508 - Temperature Sensor for Refrigerant (G454)
010 - Open or Short to Plus
01592 - Air Quality Sensor (G238)
010 - Open or Short to Plus - Intermittent
00445 - Loss of Refrigerant
015 - Cannot Be Tested at this Time

-------------------------------------------------------------------------------
Address 09: Cent. Elect. Labels: 7Lx-937-049-V1.clb
Part No: 7L6 937 049 L
Component: 2703
Coding: 0111838
Shop #: WSC 06526 444 57579
VCID: 458AE9D40FBAC71

3 Faults Found:
01517 - Control Module for Trailer/Towing Sensor (J345)
014 - Defective - Intermittent
00907 - Intervention load Management
000 - -
01520 - Rain and Light Recognition Sensor (G397)
008 - Implausible Signal - Intermittent

-------------------------------------------------------------------------------
Address 11: Engine II Labels: None
Part No SW: 070 997 016 R HW: 028 101 172 9
Component: V10 5,0L EDCG000AGSª2813
Revision: 5KO3 Serial number: VWZ3Z0D7159681
Coding: 0060575
Shop #: WSC 06526 444 84896
VCID: 2952456483E2031

1 Fault Found:
18056 - Powertrain Data Bus
P1648 - 000 - Failure - Intermittent
Freeze Frame:
RPM: 2310 /min
Torque: 110.6 Nm
Speed: 25.0 km/h
Load: 60.8 %
Voltage: 13.53 V
Bin. Bits: 00001000
(no units): 1.0


-------------------------------------------------------------------------------
Address 15: Airbags Labels: 3D0-909-601.lbl
Part No: 3D0 909 601 C
Component: 05 Airbag 8.4E++H01 0352
Revision: BB36963 Serial number: 00009349
Coding: 0012341
Shop #: WSC 31414 000 00000
VCID: 234E574CE1CED91

Part No: 7L0 959 339 B
Component: BF-Gewichtsens. 005 0006

1 Fault Found:
01312 - Powertrain Data Bus
014 - Defective - Intermittent
Freeze Frame:
Fault Status: 00101110
Fault Priority: 2
Fault Frequency: 21
Reset counter: 39
Mileage: 1048575 km
Time Indication: 0
Date: 2127.15.31
Time: 31:60:00


-------------------------------------------------------------------------------
Address 16: Steering wheel Labels: 7L6-953-549.lbl
Part No: 7L6 953 549 E
Component: Lenksäulenmodul 3301
Coding: 0000232
Shop #: WSC 31414 000 00000
VCID: 4182FDC41B92EB1

1 Fault Found:
00532 - Supply Voltage B+
002 - Lower Limit Exceeded - Intermittent

-------------------------------------------------------------------------------
Address 17: Instruments Labels: 7L6-920-xxx-7LA.lbl
Part No: 7L6 920 980 P
Component: KOMBIINSTRUMENT RB4 2935
Coding: 0023231
Shop #: WSC 06526 444 57579
VCID: 458AE9D40FBAC71

13 Faults Found:
01312 - Powertrain Data Bus
014 - Defective - Intermittent
00461 - Control Module for Seat Memory; Passenger (J521)
004 - No Signal/Communication - Intermittent
00466 - Control Module for Steering Column Electronics (J527)
004 - No Signal/Communication - Intermittent
01325 - Control Module for Tire Pressure Monitoring (J502)
004 - No Signal/Communication - Intermittent
01330 - Central Control Module for Central Convenience (J393)
004 - No Signal/Communication - Intermittent
01331 - Door Control Module; Driver Side (J386)
004 - No Signal/Communication - Intermittent
01332 - Door Control Module; Passenger Side (J387)
004 - No Signal/Communication - Intermittent
01333 - Door Control Module; Rear Left (J388)
004 - No Signal/Communication - Intermittent
01334 - Door Control Module; Rear Right (J389)
004 - No Signal/Communication - Intermittent
01335 - Drivers Seat/Mirror Position Control Module (J543)
004 - No Signal/Communication - Intermittent
01517 - Control Module for Trailer/Towing Sensor (J345)
004 - No Signal/Communication
00470 - Combination comfort Databus in Single Wire
011 - Open Circuit
01305 - Databus for Infotainment
004 - No Signal/Communication - Intermittent

-------------------------------------------------------------------------------
Address 18: Aux. Heat Labels: None
Part No: 7L6 819 008 B
Component: Standheizung E1MAC 0235
Coding: 0000030
Shop #: WSC 31414 000 00000
VCID: 356A99145F5A571

3 Faults Found:
01177 - Engine Control Unit
004 - No Signal/Communication - Intermittent
01321 - Control Module for Airbags (J234)
004 - No Signal/Communication
01126 - Engine Speed Signal
008 - Implausible Signal

-------------------------------------------------------------------------------
Address 19: CAN Gateway Labels: 6N0-909-901-19.lbl
Part No: 6N0 909 901
Component: Gateway K<>CAN 0101
Coding: 0000006
Shop #: WSC 31414 000 00000
VCID: F0E4E800E0B8B29

15 Faults Found:
01312 - Powertrain Data Bus
014 - Defective - Intermittent
00461 - Control Module for Seat Memory; Passenger (J521)
004 - No Signal/Communication - Intermittent
00466 - Control Module for Steering Column Electronics (J527)
004 - No Signal/Communication - Intermittent
01320 - Control Module for Climatronic (J255)
004 - No Signal/Communication - Intermittent
01325 - Control Module for Tire Pressure Monitoring (J502)
004 - No Signal/Communication - Intermittent
01327 - Control Module for Parking Aid (J446)
004 - No Signal/Communication - Intermittent
01330 - Central Control Module for Central Convenience (J393)
004 - No Signal/Communication - Intermittent
01331 - Door Control Module; Driver Side (J386)
004 - No Signal/Communication - Intermittent
01332 - Door Control Module; Passenger Side (J387)
004 - No Signal/Communication - Intermittent
01333 - Door Control Module; Rear Left (J388)
004 - No Signal/Communication - Intermittent
01334 - Door Control Module; Rear Right (J389)
004 - No Signal/Communication - Intermittent
01335 - Drivers Seat/Mirror Position Control Module (J543)
004 - No Signal/Communication - Intermittent
01517 - Control Module for Trailer/Towing Sensor (J345)
004 - No Signal/Communication
00470 - Combination comfort Databus in Single Wire
011 - Open Circuit
01305 - Databus for Infotainment
004 - No Signal/Communication - Intermittent

-------------------------------------------------------------------------------
Address 1C: Position Sensing Labels: 7L6-919-879.lbl
Part No: 7L6 919 879
Component: JCI PathPoint 1700
Shop #: WSC 00000 000 00000
VCID: 040C34D044003E9

No fault code found.

-------------------------------------------------------------------------------
Address 22: AWD Labels: None
Part No: 0AD 927 755 BE
Component: TRANSFERCASE 0122
Shop #: WSC 00000 000 00000
VCID: 7F06BB3C2DE65D1

1 Fault Found:
01312 - Powertrain Data Bus
014 - Defective - Intermittent

-------------------------------------------------------------------------------
Address 29: Left Light Labels: 3D0-909-157.lbl
Part No: 3D0 909 157
Component: EVG GDL+AutoLWR(l) X012
Coding: 0000003
Shop #: WSC 31414 000 00000
VCID: E6C88E58D27C6C9

No fault code found.

-------------------------------------------------------------------------------
Address 32: Differential Locks Labels: None
Part No: 0AC 927 771 B
Component: SG-Quersperre 5018
Shop #: WSC 00000 000 00000
VCID: 3776931C4556A51

6 Faults Found:
01317 - Control Module in Instrument Cluster (J285)
004 - No Signal/Communication - Intermittent
01312 - Powertrain Data Bus
014 - Defective
01314 - Engine Control Module
004 - No Signal/Communication - Intermittent
01316 - ABS Control Module
004 - No Signal/Communication - Intermittent
02053 - Control Module for Transfer Case (J646)
004 - No Signal/Communication - Intermittent
00778 - Steering Angle Sensor (G85)
004 - No Signal/Communication - Intermittent

-------------------------------------------------------------------------------
Address 34: Level Control Labels: None
Part No: 7L0 907 553 F
Component: LUFTFDR.-CDC- 3C3P1 3081
Coding: 0015521
Shop #: WSC 31414 000 00000
VCID: 36689E18425C5C9

2 Faults Found:
00778 - Steering Angle Sensor (G85)
004 - No Signal/Communication - Intermittent
01312 - Powertrain Data Bus
014 - Defective - Intermittent

-------------------------------------------------------------------------------
Address 36: Seat Mem. Drvr Labels: None
Part No: 7L0 959 760
Component: Sitzverstellung 0701
Shop #: WSC 00000 000 00000
VCID: F7F6D31C85D6E51

No fault code found.

-------------------------------------------------------------------------------
Address 37: Navigation Labels: 7L6-919-887-CD.lbl
Part No: 7L6 919 887 DX
Component: Navigation 0736
Coding: 0000002
Shop #: WSC 06526 444 59033
VCID: 9F46DBBC4DA67D1

No fault code found.

-------------------------------------------------------------------------------
Address 39: Right Light Labels: 3D0-909-158.lbl
Part No: 3D0 909 158
Component: EVG GDL+AutoLWR(r) X012
Coding: 0000003
Shop #: WSC 31414 000 00000
VCID: E7D6835CD576751

No fault code found.

-------------------------------------------------------------------------------
Address 46: Central Conv. Labels: 7L0-959-933.lbl
Part No: 7L0 959 933 E
Component: 2N HSG 0201
Coding: 0000085
Shop #: WSC 25166 444 98490
VCID: 3E7886386A6C949

Part No: 7L0 959 701 B
Component: Tuersteuergeraet FS 0201

Part No: 7L0 959 702 B
Component: Tuersteuergeraet BF 0201

Part No: 7L0 959 703 B
Component: Tuersteuergeraet HL 0201

Part No: 7L0 959 704 B
Component: Tuersteuergeraet HR 0201

8 Faults Found:
01134 - Alarm Horn (H12)
004 - No Signal/Communication - Intermittent
00470 - Combination comfort Databus in Single Wire
011 - Open Circuit
01331 - Door Control Module; Driver Side (J386)
002 - Lower Limit Exceeded - Intermittent
01332 - Door Control Module; Passenger Side (J387)
002 - Lower Limit Exceeded - Intermittent
00486 - Front Passengers Outside Door Handle Central Locking Button (E370)
007 - Short to Ground - Intermittent
01333 - Door Control Module; Rear Left (J388)
002 - Lower Limit Exceeded - Intermittent
01334 - Door Control Module; Rear Right (J389)
002 - Lower Limit Exceeded - Intermittent
00130 - Right Rear Inside Door Handle Illumination (L134)
007 - Short to Ground - Intermittent

-------------------------------------------------------------------------------
Address 47: Sound System Labels: 7Lx-035-4xx-47.lbl
Part No: 7L6 035 466
Component: 12K-AUDIOVERST 0108
Shop #: WSC 00000 000 00000
VCID: F1E2ED04EBB2BB1

1 Fault Found:
00668 - Supply Voltage Terminal 30
002 - Lower Limit Exceeded - Intermittent

-------------------------------------------------------------------------------
Address 56: Radio Labels: 7L6-035-186-CD.lbl
Part No: 7L6 035 186 AX
Component: Radio 0736
Coding: 0005077
Shop #: WSC 06526 444 57579
VCID: 8912A5E4E322E31

No fault code found.

-------------------------------------------------------------------------------
Address 65: Tire Pressure Labels: 7L6-907-273.lbl
Part No: 7L6 907 273
Component: Reifendruckueberw. 0052
Coding: 0210390
Shop #: WSC 03155 444 54064
VCID: F5EAD9149FDA971

2 Faults Found:
01507 - Initialization Not Successful
000 - - - Intermittent - MIL ON
01521 - Sensor for Tire Pressure
004 - No Signal/Communication - Intermittent - MIL ON

-------------------------------------------------------------------------------
Address 68: Wiper Electr. Labels: None
Part No: 7L0 955 119 F
Component: Front Wiper 2416
Coding: 0000003
Shop #: WSC 00000 000 00000
VCID: 3776931C4556A51

1 Fault Found:
01024 - Rain Sensor (G213)
014 - Defective

-------------------------------------------------------------------------------
Address 6E: Ctrl Head Roof Labels: 7L6-919-044.lbl
Part No: 7L6 919 044 G
Component: DACHDISPLAY 0530
Revision: 00600530 Serial number: 2009268.03
Shop #: WSC 31414 000 00000
VCID: 3B7E8F2C797E811

1 Fault Found:
01305 - Databus for Infotainment
004 - No Signal/Communication - Intermittent

-------------------------------------------------------------------------------
Address 75: Telematics Labels: 3D0-035-617.lbl
Part No SW: 3D0 035 617 B HW: 3D0 035 617 B
Component: Telematik NAR1 0104
Coding: 0076510
Shop #: WSC 06531 406 00561
VCID: 1F465BBCCDA6FD1

2 Faults Found:
01321 - Control Module for Airbags (J234)
004 - No Signal/Communication - MIL ON
00003 - Control Module
014 - Defective - MIL ON

-------------------------------------------------------------------------------
Address 76: Park Assist Labels: 3D0-919-283.lbl
Part No: 7L0 919 283 E
Component: 0E Einparkhilfe 0907
Shop #: WSC 00000 000 00000
VCID: 387490204848AA9

2 Faults Found:
01548 - Sensor for Parking Aid; Rear Right (G206)
014 - Defective - Intermittent
01517 - Control Module for Trailer/Towing Sensor (J345)
004 - No Signal/Communication

End ---------------------------------------------------------------------
 
A

alphaseinor

TDI Innovator, Gone but Not Forgotten
Joined
Jul 30, 2006
Location
Denton, TX
TDI
'03 Jetta TDI 780,000 miles (totaled out), 01 Audi TT 225 Quattro 230,000 Miles (runs great!), 00 Cabreetle Beetle dash, ALH & MK4 harness Swap
That's what I've been looking at for about a week...
 
oilhammer

oilhammer

Certified Volkswagen Nut & Vendor
Joined
Dec 11, 2001
Location
outside St Louis, MO
TDI
There are just too many to list....
Pull the wire harness loose from the driver's side kick panel, look for a bad splice. There is a TSB, 97-09-02 "no CAN communications".

Let me know if you need more info I can fax it.

Club Touareg may also have this TSB in .pdf form.
 
Last edited:
You must log in or register to reply here.
Top