Search results

I fixed it with diesel clean. Ken 2001 golf

The stepper motor is bad...

AC problems fixed OK guys. if you go get you AC serviced it will be $1600.00. So do it all yourself. I find the cheapest parts off of eBay. You can get a complete kit to fix you AC from eBay. The best part is the price from $110 to $150. you get all the parts you need to get cold really cold...

If the seals are good in the IP... Uhhh replace the check valve (or get it working) on the return line on the injection pump. There's your problem! If the check valve on the output of the injection is clear you will always prime the pump in under two minutes.

Uhhh replace the check valve (or get it working) on the return line on the injection pump. there's your problem!

$2.79 / Gallon here in Sacramento California. I can't believe it either!

1. dlai, 2005 Passat, South San Francisco 2. Peter Pyce, 2002 Jetta, Mountain View 3. Peter Cheuk, 1998 Jetta, Daly City 4. bogstomper, 1998 Jetta, San Francisco 5. Norman, 2000 Golf, San Jose 6. First D, 2002 Jetta, Anaheim 7. eetsoot, 2002 Jetta, Oxnard 8. Hesh, 2000 Golf, La Honda 9. NewTDI...

2003 Jetta TDI automatic. 204,000 miles. Just had to fix a disconnected vacuum line. $3500

Nice to see people interested in this thread. I'm a ham radio operator so when there is no cell phone connection I'll be using the ham radio for status update. Hope to see if Clint can post the status for us while we are on the road. Enjoy All!

2003 Wagon I had the VW rough rider spacers for years. For putting them on Bilsten HDs I had to add spacers on the threaded part of the shaft to make up the gap so the strut bearing would not get crushed. The front is using VR6 springs which has a few pounds of extra lift. The same shaft...

2003 TDI Wagon I now has new 21575R15 BFG Mud Terrain tires, 1/2 inch lift on all four wheels, New MAF, New Bilstein HD shocks, new rear brakes, flushed brake fluid, flushed power steering system, 5 brake light upgrade installed, new rear badge. Next is to change the fuel filter and the oil.:p

I'm putting 215/75R15 BFG's onto my wifes 2003 Jetta Wagon :D We are planning to drive all over Alaska in the summer...

Definitely change the Thermostat. I just did that on my 2003 Golf. my mileage went back up to where it should be. to check it I drove 59 mph on cruise over a two week time. I got 62.8 mpg. (of course I have mods to give me better mpg). Before the thermostat changed I was getting 47 MPG. After...

I have a 2003 Golf TDI. I just fixed the o-ring on the injection pump and replaced the bad thermostat. Here is how I did it…. Install a VNT 17/22 Turbo. Install RocketChip2 firmware. Install a 5th Gear mod. Repaired the injection pump leak. Replaced the thermostat. Cruise at 59 MPH. The...

If I make it to WY i'll let you know :rolleyes:

Hello, I'm looking for an older non turbo IDI engine :rolleyes:. I need the complete engine so I can easily get it running. Anybody in California have one they want to get rid of it?

n8ronj, How many miles do you drive in a one way trip? I'm driving 47 miles one way. I do have the 5th gear mod which lowers my RPM by 400 at around 60 MPH. My car is 'chipped' also but I don't know if it helps. It does let me get out of the way of some idiots. I leave it in gear as much as...

Miles: 921.1 Gallons: 16.193 Model Year: 2003 Model: Golf Tranny: 5M+ Fuel Type: Normal Diesel II MPG: 56.88 Mostly freeway driving with 47 mile trips at about 60 to 62 mph with some stop and go traffic. Tank light came on at 861.4 miles. The engine is at 1775 rpm at 60mph with the 5th gear...

2003 Golf GL TDI, 5th gear mod, chip tune

Driver: KRMason Miles: 768.8 Gallons: 15.699 Model Year: 2003 Model: Golf GL 4 door Tranny: 5M Fuel Type: ULSD MPG: 48.97 To drive to work I drive @80 MPH for 32 miles. Climb a 10% grade hill for 9 miles as fast as traffic, usually 75 MPH. Surface streets are 6 miles. Wife drove the car so...