dugjones
Member
Hi all,
So I just finished swapping out the EGR filter and the DPF on my Jetta MK6 (thanks to those who answered my questions!) due to P0401 and P2002 codes (and black soot on tailpipe). After swap and reset of codes seemed fine on some short drives (was even getting close to 50mpg on the highway again) but then the SEL came on and I got a P0471.
I checked the sensor directly behind the oil fill and did notice I didn't have one of the tubes all the way on so corrected that. Cleared codes and continued driving and today on my way home the SEL soon came on and the glow plug light started flashing. I also seemed to lose power (but didn't feel as bad as limp mode the first time I experienced that).
I opened a new thread because I feel like this is a new issue so if that is bad form my apologies.
Any help troubleshooting this is greatly appreciated. I have a lot of $$ wrapped up in repairs lately and this is really starting to hurt. Also I am going to open a separate thread with a question on the DSG portion.
Below is what the scan revealed (I excluded no fault sections):
Chassis Type: AJ-VW36 (6N0)
Scan: 01 02 03 08 09 15 17 19 25 2E 44 56 77
VIN: 3VWLL7AJ3BM025704 Mileage: 327950km-203778miles
01-Engine -- Status: Malfunction 0010
02-Auto Trans -- Status: Malfunction 0010
03-ABS Brakes -- Status: OK 0000
04-Steering Angle -- Status: OK 0000
08-Auto HVAC -- Status: OK 0000
09-Cent. Elect. -- Status: Malfunction 0010
15-Airbags -- Status: OK 0000
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: OK 0000
25-Immobilizer -- Status: OK 0000
2E-Media Player 3 -- Status: OK 0000
44-Steering Assist -- Status: OK 0000
56-Radio -- Status: Malfunction 0010
77-Telephone -- Status: OK 0000
-------------------------------------------------------------------------------
Address 01: Engine (CJA) Labels: 03L-906-022-CBE.clb
Part No SW: 03L 997 030 P HW: 03L 906 019 DA
Component: R4 2.0l TDI G000AG 9983
Revision: 12H10--- Serial number:
Coding: 0050078
Shop #: WSC 64109 003 1048576
VCID: 3B233A68BF6F7FD3FE0-806E
VINID: 0E69DC70745A0D27400851C010418FA861
5 Faults Found:
001137 - Exhaust Pressure Sensor 1
P0471 - 000 - Implausible Signal - Intermittent - MIL ON
Freeze Frame:
Fault Status: 10100000
Fault Priority: 2
Fault Frequency: 10
Reset counter: 255
Mileage: 327899 km
Time Indication: 0
Date: 2017.07.09
Time: 18:11:26
Freeze Frame:
RPM: 2346 /min
Speed: 118.0 km/h
Temperature: 19.8°C
Temperature: 76.5°C
Temperature: 114.0°C
Pressure: -41 mbar
Pressure: 13 mbar
009231 - Exhaust Gas Recirculation System
P240F - 000 - Response too Slow - MIL ON
Freeze Frame:
Fault Status: 11100000
Fault Priority: 2
Fault Frequency: 1
Reset counter: 255
Mileage: 327901 km
Time Indication: 0
Date: 2017.07.09
Time: 18:12:41
Freeze Frame:
RPM: 2139 /min
Speed: 109.0 km/h
Load: 87.1 %
Mass Air / Rev.: 0.0 mg/str
Mass Air / Rev.: 25.0 mg/str
Mass Air / Rev.: 325.0 mg/str
Mass Air / Rev.: 420.0 mg/str
001025 - EGR System
P0401 - 001 - Insufficient Flow - Intermittent - MIL ON
Freeze Frame:
Fault Status: 10100001
Fault Priority: 2
Fault Frequency: 2
Reset counter: 255
Mileage: 327924 km
Time Indication: 0
Date: 2017.07.09
Time: 21:03:43
Freeze Frame:
RPM: 1518 /min
Speed: 63.0 km/h
Voltage: 13.98 V
Load: 87.1 %
Load: 100.0 %
Mass Air / Rev.: 335.0 mg/str
Mass Air / Rev.: 465.0 mg/str
000665 - Boost Pressure Regulation
P0299 - 000 - Control Range Not Reached - MIL ON
Freeze Frame:
Fault Status: 11100000
Fault Priority: 2
Fault Frequency: 1
Reset counter: 255
Mileage: 327943 km
Time Indication: 0
Date: 2017.07.09
Time: 15:41:55
Freeze Frame:
RPM: 2093 /min
Speed: 106.0 km/h
Load: 68.2 %
Pressure: 2395.8 mbar
Pressure: 1669.8 mbar
Lambda: 85.2 %
Lambda: 84.4 %
000665 - Boost Pressure Regulation
P0299 - 001 - Control Range Not Reached
Freeze Frame:
Fault Status: 01100001
Fault Priority: 2
Fault Frequency: 1
Reset counter: 255
Mileage: 327943 km
Time Indication: 0
Date: 2017.07.09
Time: 15:41:55
Freeze Frame:
RPM: 2093 /min
Speed: 106.0 km/h
Load: 68.2 %
Pressure: 2395.8 mbar
Pressure: 1669.8 mbar
Lambda: 85.2 %
Lambda: 84.4 %
Readiness: 1 3 0 0 0
-------------------------------------------------------------------------------
Address 02: Auto Trans Labels: 02E-927-770.clb
Part No SW: 02E 300 052 G HW: 02E 927 770 AL
Component: GSG DSG AG6 511 9136
Revision: 05151112 Serial number: 00001008130562
Coding: 0000020
Shop #: WSC 00066 000 00000
VCID: 1869C5E4EE9974CB332-804C
1 Fault Found:
18149 - Clutch Pressure Adaptation
P1741 - 002 - Limit Reached - Intermittent
Freeze Frame:
Fault Status: 00100010
Fault Priority: 0
Fault Frequency: 255
Reset counter: 2
Mileage: 327919 km
Time Indication: 0
Date: 2017.07.09
Time: 20:59:37
Address 09: Cent. Elect. (J519) Labels:. 6R0-937-08x-09.clb
Part No SW: 5C0 937 087 E HW: 5C0 937 087 A
Component: BCM25 JLB H3 H66 0257
Revision: B2066001 Serial number: 03311286100308
Coding: 7B994B9A08A30B0008382000240884C50082502E60000000300000000000
Shop #: WSC 10123 002 1048576
VCID: 2F3B1E3877179373428-807A
Subsystem 1 - Part No SW: 6R0 959 801 M HW: 6R0 959 801 M Labels: 6R0-959-801.CLB
Component: J386__TSG_FT 002 3463
Serial number: --------------------
Coding: 820000
Subsystem 2 - Part No SW: 6R0 959 802 P HW: 6R0 959 802 P Labels: 6R0-959-802.CLB
Component: J387__TSG_BT 002 3463
Serial number: --------------------
Coding: 820000
Subsystem 3 - Part No SW: 5K0 959 591 HW: 5K0 959 591
Component: J245 PS41.019 H08 0006
Serial number: WRH0000GZ2N
Coding: 180000
Subsystem 4 - Part No SW: 5K0 959 542 HW: 5K0 959 542
Component: E221__MFL-TAS H05 0010
Serial number: 0138442
Coding: 020000
Subsystem 5 - Part No SW: 6R0 959 811 D HW: 6R0 959 811 D
Component: J388__TSG_HL 002 3463
Serial number: --------------------
Coding: 800000
Subsystem 6 - Part No SW: 6R0 959 812 D HW: 6R0 959 812 D
Component: J389__TSG_HR 002 3463
Serial number: --------------------
Coding: 800000
1 Fault Found:
03444 - Ignition Starter Switch
008 - Implausible Signal - Intermittent
Freeze Frame:
Fault Status: 00101000
Fault Priority: 3
Fault Frequency: 2
Reset counter: 70
Mileage: 327482 km
Time Indication: 0
Date: 2017.07.09
Time: 15:43:44
Address 56: Radio (J503) Labels:. 5M0-035-1xx-56.clb
Part No SW: 1K0 035 180 AC HW: 1K0 035 180 AC
Component: Radio Prem-8 H10 0045
Revision: -----19S Serial number: VWZ4Z7J3028815
Coding: 0000000001
Shop #: WSC 00066 123 12345
VCID: 619FA8007143750384C-8034
1 Fault Found:
02635 - Tuner Not Enabled/Activated
000 - -
Freeze Frame:
Fault Status: 01100000
Fault Priority: 7
Fault Frequency: 4
Reset counter: 36
Mileage: 315883 km
Time Indication: 0
Date: 2017.07.09
Time: 10:06:56
So I just finished swapping out the EGR filter and the DPF on my Jetta MK6 (thanks to those who answered my questions!) due to P0401 and P2002 codes (and black soot on tailpipe). After swap and reset of codes seemed fine on some short drives (was even getting close to 50mpg on the highway again) but then the SEL came on and I got a P0471.
I checked the sensor directly behind the oil fill and did notice I didn't have one of the tubes all the way on so corrected that. Cleared codes and continued driving and today on my way home the SEL soon came on and the glow plug light started flashing. I also seemed to lose power (but didn't feel as bad as limp mode the first time I experienced that).
I opened a new thread because I feel like this is a new issue so if that is bad form my apologies.
Any help troubleshooting this is greatly appreciated. I have a lot of $$ wrapped up in repairs lately and this is really starting to hurt. Also I am going to open a separate thread with a question on the DSG portion.
Below is what the scan revealed (I excluded no fault sections):
Chassis Type: AJ-VW36 (6N0)
Scan: 01 02 03 08 09 15 17 19 25 2E 44 56 77
VIN: 3VWLL7AJ3BM025704 Mileage: 327950km-203778miles
01-Engine -- Status: Malfunction 0010
02-Auto Trans -- Status: Malfunction 0010
03-ABS Brakes -- Status: OK 0000
04-Steering Angle -- Status: OK 0000
08-Auto HVAC -- Status: OK 0000
09-Cent. Elect. -- Status: Malfunction 0010
15-Airbags -- Status: OK 0000
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: OK 0000
25-Immobilizer -- Status: OK 0000
2E-Media Player 3 -- Status: OK 0000
44-Steering Assist -- Status: OK 0000
56-Radio -- Status: Malfunction 0010
77-Telephone -- Status: OK 0000
-------------------------------------------------------------------------------
Address 01: Engine (CJA) Labels: 03L-906-022-CBE.clb
Part No SW: 03L 997 030 P HW: 03L 906 019 DA
Component: R4 2.0l TDI G000AG 9983
Revision: 12H10--- Serial number:
Coding: 0050078
Shop #: WSC 64109 003 1048576
VCID: 3B233A68BF6F7FD3FE0-806E
VINID: 0E69DC70745A0D27400851C010418FA861
5 Faults Found:
001137 - Exhaust Pressure Sensor 1
P0471 - 000 - Implausible Signal - Intermittent - MIL ON
Freeze Frame:
Fault Status: 10100000
Fault Priority: 2
Fault Frequency: 10
Reset counter: 255
Mileage: 327899 km
Time Indication: 0
Date: 2017.07.09
Time: 18:11:26
Freeze Frame:
RPM: 2346 /min
Speed: 118.0 km/h
Temperature: 19.8°C
Temperature: 76.5°C
Temperature: 114.0°C
Pressure: -41 mbar
Pressure: 13 mbar
009231 - Exhaust Gas Recirculation System
P240F - 000 - Response too Slow - MIL ON
Freeze Frame:
Fault Status: 11100000
Fault Priority: 2
Fault Frequency: 1
Reset counter: 255
Mileage: 327901 km
Time Indication: 0
Date: 2017.07.09
Time: 18:12:41
Freeze Frame:
RPM: 2139 /min
Speed: 109.0 km/h
Load: 87.1 %
Mass Air / Rev.: 0.0 mg/str
Mass Air / Rev.: 25.0 mg/str
Mass Air / Rev.: 325.0 mg/str
Mass Air / Rev.: 420.0 mg/str
001025 - EGR System
P0401 - 001 - Insufficient Flow - Intermittent - MIL ON
Freeze Frame:
Fault Status: 10100001
Fault Priority: 2
Fault Frequency: 2
Reset counter: 255
Mileage: 327924 km
Time Indication: 0
Date: 2017.07.09
Time: 21:03:43
Freeze Frame:
RPM: 1518 /min
Speed: 63.0 km/h
Voltage: 13.98 V
Load: 87.1 %
Load: 100.0 %
Mass Air / Rev.: 335.0 mg/str
Mass Air / Rev.: 465.0 mg/str
000665 - Boost Pressure Regulation
P0299 - 000 - Control Range Not Reached - MIL ON
Freeze Frame:
Fault Status: 11100000
Fault Priority: 2
Fault Frequency: 1
Reset counter: 255
Mileage: 327943 km
Time Indication: 0
Date: 2017.07.09
Time: 15:41:55
Freeze Frame:
RPM: 2093 /min
Speed: 106.0 km/h
Load: 68.2 %
Pressure: 2395.8 mbar
Pressure: 1669.8 mbar
Lambda: 85.2 %
Lambda: 84.4 %
000665 - Boost Pressure Regulation
P0299 - 001 - Control Range Not Reached
Freeze Frame:
Fault Status: 01100001
Fault Priority: 2
Fault Frequency: 1
Reset counter: 255
Mileage: 327943 km
Time Indication: 0
Date: 2017.07.09
Time: 15:41:55
Freeze Frame:
RPM: 2093 /min
Speed: 106.0 km/h
Load: 68.2 %
Pressure: 2395.8 mbar
Pressure: 1669.8 mbar
Lambda: 85.2 %
Lambda: 84.4 %
Readiness: 1 3 0 0 0
-------------------------------------------------------------------------------
Address 02: Auto Trans Labels: 02E-927-770.clb
Part No SW: 02E 300 052 G HW: 02E 927 770 AL
Component: GSG DSG AG6 511 9136
Revision: 05151112 Serial number: 00001008130562
Coding: 0000020
Shop #: WSC 00066 000 00000
VCID: 1869C5E4EE9974CB332-804C
1 Fault Found:
18149 - Clutch Pressure Adaptation
P1741 - 002 - Limit Reached - Intermittent
Freeze Frame:
Fault Status: 00100010
Fault Priority: 0
Fault Frequency: 255
Reset counter: 2
Mileage: 327919 km
Time Indication: 0
Date: 2017.07.09
Time: 20:59:37
Address 09: Cent. Elect. (J519) Labels:. 6R0-937-08x-09.clb
Part No SW: 5C0 937 087 E HW: 5C0 937 087 A
Component: BCM25 JLB H3 H66 0257
Revision: B2066001 Serial number: 03311286100308
Coding: 7B994B9A08A30B0008382000240884C50082502E60000000300000000000
Shop #: WSC 10123 002 1048576
VCID: 2F3B1E3877179373428-807A
Subsystem 1 - Part No SW: 6R0 959 801 M HW: 6R0 959 801 M Labels: 6R0-959-801.CLB
Component: J386__TSG_FT 002 3463
Serial number: --------------------
Coding: 820000
Subsystem 2 - Part No SW: 6R0 959 802 P HW: 6R0 959 802 P Labels: 6R0-959-802.CLB
Component: J387__TSG_BT 002 3463
Serial number: --------------------
Coding: 820000
Subsystem 3 - Part No SW: 5K0 959 591 HW: 5K0 959 591
Component: J245 PS41.019 H08 0006
Serial number: WRH0000GZ2N
Coding: 180000
Subsystem 4 - Part No SW: 5K0 959 542 HW: 5K0 959 542
Component: E221__MFL-TAS H05 0010
Serial number: 0138442
Coding: 020000
Subsystem 5 - Part No SW: 6R0 959 811 D HW: 6R0 959 811 D
Component: J388__TSG_HL 002 3463
Serial number: --------------------
Coding: 800000
Subsystem 6 - Part No SW: 6R0 959 812 D HW: 6R0 959 812 D
Component: J389__TSG_HR 002 3463
Serial number: --------------------
Coding: 800000
1 Fault Found:
03444 - Ignition Starter Switch
008 - Implausible Signal - Intermittent
Freeze Frame:
Fault Status: 00101000
Fault Priority: 3
Fault Frequency: 2
Reset counter: 70
Mileage: 327482 km
Time Indication: 0
Date: 2017.07.09
Time: 15:43:44
Address 56: Radio (J503) Labels:. 5M0-035-1xx-56.clb
Part No SW: 1K0 035 180 AC HW: 1K0 035 180 AC
Component: Radio Prem-8 H10 0045
Revision: -----19S Serial number: VWZ4Z7J3028815
Coding: 0000000001
Shop #: WSC 00066 123 12345
VCID: 619FA8007143750384C-8034
1 Fault Found:
02635 - Tuner Not Enabled/Activated
000 - -
Freeze Frame:
Fault Status: 01100000
Fault Priority: 7
Fault Frequency: 4
Reset counter: 36
Mileage: 315883 km
Time Indication: 0
Date: 2017.07.09
Time: 10:06:56