Ok finally got the replacement engine installed
new turbo
new timing belt kit, including water pump ect
new cam and lifters
pd150 intake
plugged vacumm lines that went to egr
changed out dual pump
I installed engine, decided to do a test start,so plugged in all plugs and vacumn lines to engine and trans put long water hose from inlet to outlet.
cycled ign.until fuel came out of return line new oil filter and oil
turned engine over without glow plugs in to get oil pumping and fuel to injectors
moment of truth, after about 5 tries it started trying to start finally it started. I shut it down after about 10 secs to check oil and ps fluid level all was good
went to start again and shut down immediatly after about 5 tries battery was down
charged battery overnight and tried again. same started then died. read that low battery would kick in immobilezer so touched cables together for 15 secs and held brake down as per immobilezer reset
didnt get a chance to install run all new battery for 4 days
Got battery installed it started first crank let it run for a few then shut down did that a couple more times then it started immedietly dying again checked dash for immobilezer light and it went off before i cranked
all help would be appreciated Here is my scan
Sunday,03,February,2019,11:34:23:60489
VCDS -- Windows Based VAG/VAS Emulator Running on Windows 7 x64
VCDS Version: 18.9.1.0 (x64)
Data version: 20190114 DS296.0
www.Ross-Tech.com
VIN: License Plate:
Chassis Type: 1C (1C - VW New Beetle (1998 > 2010))
Scan: 01 02 03 08 15 17 19 25 29 35 37 39 46 54 56 65 75
VIN: Mileage: 346000km-214994miles
-------------------------------------------------------------------------------
Address 01: Engine Labels: 038-906-016-BEW.lbl
Part No SW: 038 997 016 M HW: 028 101 114 7
Component: R4 1,9L EDC G000DG 2878
Revision: 12345678 Serial number: VWZ5Z0CD182110
Coding: 0150038
Shop #: WSC 26093 444 53667
VCID: 28412FBA981F520AB5-515A
4 Faults Found:
16791 - EGR Sensor 2
P0407 - 000 - Signal too Low
Freeze Frame:
RPM: 0 /min
Torque: 0.0 Nm
Speed: 0.0 km/h
Load: 0.0 %
Lambda: -2.5 %
Mass Air / Rev.: 1000.0 mg/str
Mass Air / Rev.: 0.0 mg/str
Bin. Bits: 00000000
19558 - Motor for Intake Manifold Flap (V157)
P3102 - 000 - No Signal
Freeze Frame:
RPM: 0 /min
Torque: 0.0 Nm
Speed: 0.0 km/h
Load: 0.0 %
Voltage: 12.62 V
Bin. Bits: 00001100
Torque: 0.0 Nm
Torque: 110.0 Nm
19557 - Motor for Intake Manifold Flap (V157)
P3101 - 000 - Open or Short to Ground
Freeze Frame:
RPM: 0 /min
Torque: 0.0 Nm
Speed: 0.0 km/h
Load: 0.0 %
Voltage: 12.54 V
Bin. Bits: 00001100
Torque: 0.0 Nm
Torque: 110.0 Nm
16486 - Mass Air Flow Sensor (G70)
P0102 - 000 - Signal too Low
Freeze Frame:
RPM: 168 /min
Torque: 0.0 Nm
Speed: 0.0 km/h
Load: 0.0 %
Duty Cycle: 100.6 %
Bin. Bits: 00001100
Mass Air / Rev.: 1000.0 mg/str
Mass Air / Rev.: 0.0 mg/str
Readiness: 1 4 0 1 1
-------------------------------------------------------------------------------
Address 02: Auto Trans Labels: 02E-927-770.clb
Part No SW: 02E 300 041 S HW: 02E 927 770 AD
Component: GSG DSG 082 0806
Revision: 05308020 Serial number: 00001105231793
Coding: 0000020
Shop #: WSC 04940 551 00000
VCID: 22553D92FE23B85AEB-515A
No fault code found.
-------------------------------------------------------------------------------
Address 03: ABS Brakes Labels: 1C0-907-37x-ASR.lbl
Part No: 1C0 907 379 K
Component: ASR FRONT MK60 0103
Coding: 0018945
Shop #: WSC 00066 000 00000
VCID: 3275CDD2AEC328DA1B-51D0
No fault code found.
-------------------------------------------------------------------------------
Address 15: Airbags Labels: 1T0-909-605.lbl
Part No: 6Q0 909 605 AG
Component: 01 AIRBAG VW71 0710
Coding: 0012337
Shop #: WSC 00066 000 00000
VCID: 7CE923EA3C072EAA81-515A
Subsystem 1 - Part No: 1C0 959 339
Component: BF-Gewichtsens. 004 0004
1 Fault Found:
00532 - Supply Voltage B+
002 - Lower Limit Exceeded - Intermittent
-------------------------------------------------------------------------------
Address 17: Instruments Labels: 1C0-920-x4x.lbl
Part No: 1C0 920 951 M
Component: KOMBI+WEGFAHRS. M73 V02
Coding: 01234
Shop #: WSC 20112
VCID: 2B4BD0B6D9E9791258-4B64
VWZ5Z0CD182110
No fault code found.
-------------------------------------------------------------------------------
Address 19: CAN Gateway Labels: 6N0-909-901-19.lbl
Part No: 6N0 909 901
Component: Gateway K<->CAN V022
Coding: 00006
Shop #: WSC 00066
VCID: 70F107DA304F5ACA2D-4B00
No fault code found.
-------------------------------------------------------------------------------
Address 46: Central Conv. Labels: 1C0-959-799.lbl
Part No: 1C0 959 799 G
Component: 2K Komfortgerát HLO 0004
Coding: 00065
Shop #: WSC 26085
VCID: 3B6BE0F62989E992C8-4B00
Subsystem 1 - Part No: 1C2959802A
Component: 2K Tõrsteuer.FS KLO 0202
Subsystem 2 - Part No: 1C2959801A
Component: 2K Tõrsteuer.BF KLO 0202
8 Faults Found:
01330 - Central Control Module for Central Convenience (J393)
53-10 - Supply Voltage Too Low - Intermittent
00928 - Locking Module for Central Locking; Front Driver Side (F220)
54-10 - Incorrectly Equipped - Intermittent
00929 - Locking Module for Central Locking; Front Passenger Side (F221)
54-10 - Incorrectly Equipped - Intermittent
01044 - Control Module Incorrectly Coded
35-00 - -
00912 - Window Regulator Switch; Front Left (E40)
27-10 - Implausible Signal - Intermittent
01331 - Door Control Module; Driver Side (J386)
37-00 - Faulty
01359 - Internal Central Locking Switch; Passenger Side (E198)
27-10 - Implausible Signal - Intermittent
01332 - Door Control Module; Passenger Side (J387)
37-00 - Faulty
-------------------------------------------------------------------------------
Address 56: Radio Labels: 1J0-035-18x-56.lbl
Part No: 1C0 035 196 H
Component: RADIO DE2 0004
Coding: 06031
Shop #: WSC 00066
VCID: 24593B8AB437B66A99-51D0
2 Faults Found:
65535 - Internal Control Module Memory Error
00-10 - - - Intermittent
00668 - Supply Voltage Terminal 30
07-00 - Signal too Low
End-------------------------(Elapsed Time: 03:56)--------------------------