fdizz
Veteran Member
After talking my Wife into getting a tdi jetta, we have had nothing but problems with it. Now I'm no tdi hater, had a 2010 golf i put 250k on then sold it back then bought my current car a 2015 tdi golf . Last Saturday the glow plug light flashed and car went into limp mode. We pulled over, shut the car off and turned it back on and it was normal. drove 30 miles home and then drove it all Sunday with no issues.
Then Monday it happened again. If we shut the car off it goes away upon restart. So I said screw it and dropped it off at the dealer. 6 hours later they called saying the fuel tested positive for petrol in it. I told them off as ive been the only one filling the car, with diesel, at the same station every time. They said ok and they were going to call vwoa to see if they'd cover it. we don't hear from them for 3 days and then they called my wife this last Friday saying they fixed it under warranty and it was ready to go. So naturally I called them and they told me they dug into it further and replaced the fuel rail and sensor.
So yesterday I go pick it up and drove it 100 miles with no issues. Then last night i go pick my wife up from work and while I'm waiting i ran an autoscan on it via vcds. The 2 P0087 low fuel pressure codes were gone from last Saturday and Monday but there was one from Thursday at 1:02 pm. At this time the car was still in control of the dealer. As we leave the wife's work, boom it does it again. Flashing glow plug, limp mode. Shut it off, back on, 30 miles home all good. ***. I scanned it, same low pressure code. Any ideas?? Bringing it back to the dealer tomorrow. Making them give me an alltrac for a loaner haha. Ive attached a pic of the work order and the auto scans below.
VCDS:
Saturday,02,February,2019,19:30:36:42496
VCDS -- Windows Based VAG/VAS Emulator Running on Windows 10 x64
VCDS Version: 18.9.1.0 (x64) HEX-V2 CB: 0.4437.4
Data version: 20190114 DS296.0
www.Ross-Tech.com
VIN: 3VWLL7AJ5EM337267 License Plate:
Mileage: 66290km-41190mi Repair Order:
--------------------------------------------------------------------------------
--------------------------------------------------------------------------------
Chassis Type: AJ-VW36 (6N0)
Scan: 01 02 03 05 08 09 15 17 19 25 2B 2E 37 44 47 56 75 77
VIN: 3VWLL7AJ5EM337267 Mileage: 66290km-41190miles
01-Engine -- Status: Malfunction 0010
02-Auto Trans -- Status: OK 0000
03-ABS Brakes -- Status: OK 0000
04-Steering Angle -- Status: OK 0000
05-Acc/Start Auth. -- Status: OK 0000
08-Auto HVAC -- Status: OK 0000
09-Cent. Elect. -- Status: OK 0000
15-Airbags -- Status: OK 0000
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: OK 0000
25-Immobilizer -- Status: OK 0000
2B-Steer. Col. Lock -- Status: OK 0000
2E-Media Player 3 -- Status: OK 0000
37-Navigation -- Status: Malfunction 0010
44-Steering Assist -- Status: OK 0000
47-Sound System -- Status: OK 0000
56-Radio -- Status: OK 0000
75-Telematics -- Status: Malfunction 0010
77-Telephone -- Status: OK 0000
-------------------------------------------------------------------------------
Address 01: Engine (CJA) Labels: 03L-906-022-CBE.clb
Part No SW: 03L 997 030 M HW: 03L 907 309 AA
Component: R4 2.0l TDI G000AG 9983
Revision: 12H16--- Serial number:
Coding: 0050078
Shop #: WSC 43585 002 1048576
VCID: 38292A989E59EBC766D-806C
2 Faults Found:
000135 - Fuel Rail/System Pressure
P0087 - 001 - Too Low - Intermittent
Freeze Frame:
Fault Status: 00100001
Fault Priority: 2
Fault Frequency: 1
Reset counter: 255
Mileage: 66097 km
Time Indication: 0
Date: 2019.01.31
Time: 01:02:06
Freeze Frame:
RPM: 1495 /min
Inj. Quantity: 45.0 mg/str
(no units): 5.0
Pressure: 1224.0 bar
Pressure: 840.0 bar
Temperature: 26.1°C
Tank Cont.: 47.6 l
000135 - Fuel Rail/System Pressure
P0087 - 004 - Too Low - Intermittent
Freeze Frame:
Fault Status: 00100100
Fault Priority: 2
Fault Frequency: 1
Reset counter: 255
Mileage: 66252 km
Time Indication: 0
Date: 2019.02.02
Time: 06:29:20
Freeze Frame:
RPM: 1656 /min
Inj. Quantity: 36.5 mg/str
(no units): 4.0
Pressure: 1368.0 bar
Pressure: 1072.0 bar
Temperature: 33.3°C
Tank Cont.: 36.4 l
Readiness: 0 0 0 0 0
Then Monday it happened again. If we shut the car off it goes away upon restart. So I said screw it and dropped it off at the dealer. 6 hours later they called saying the fuel tested positive for petrol in it. I told them off as ive been the only one filling the car, with diesel, at the same station every time. They said ok and they were going to call vwoa to see if they'd cover it. we don't hear from them for 3 days and then they called my wife this last Friday saying they fixed it under warranty and it was ready to go. So naturally I called them and they told me they dug into it further and replaced the fuel rail and sensor.
So yesterday I go pick it up and drove it 100 miles with no issues. Then last night i go pick my wife up from work and while I'm waiting i ran an autoscan on it via vcds. The 2 P0087 low fuel pressure codes were gone from last Saturday and Monday but there was one from Thursday at 1:02 pm. At this time the car was still in control of the dealer. As we leave the wife's work, boom it does it again. Flashing glow plug, limp mode. Shut it off, back on, 30 miles home all good. ***. I scanned it, same low pressure code. Any ideas?? Bringing it back to the dealer tomorrow. Making them give me an alltrac for a loaner haha. Ive attached a pic of the work order and the auto scans below.
VCDS:
Saturday,02,February,2019,19:30:36:42496
VCDS -- Windows Based VAG/VAS Emulator Running on Windows 10 x64
VCDS Version: 18.9.1.0 (x64) HEX-V2 CB: 0.4437.4
Data version: 20190114 DS296.0
www.Ross-Tech.com
VIN: 3VWLL7AJ5EM337267 License Plate:
Mileage: 66290km-41190mi Repair Order:
--------------------------------------------------------------------------------
--------------------------------------------------------------------------------
Chassis Type: AJ-VW36 (6N0)
Scan: 01 02 03 05 08 09 15 17 19 25 2B 2E 37 44 47 56 75 77
VIN: 3VWLL7AJ5EM337267 Mileage: 66290km-41190miles
01-Engine -- Status: Malfunction 0010
02-Auto Trans -- Status: OK 0000
03-ABS Brakes -- Status: OK 0000
04-Steering Angle -- Status: OK 0000
05-Acc/Start Auth. -- Status: OK 0000
08-Auto HVAC -- Status: OK 0000
09-Cent. Elect. -- Status: OK 0000
15-Airbags -- Status: OK 0000
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: OK 0000
25-Immobilizer -- Status: OK 0000
2B-Steer. Col. Lock -- Status: OK 0000
2E-Media Player 3 -- Status: OK 0000
37-Navigation -- Status: Malfunction 0010
44-Steering Assist -- Status: OK 0000
47-Sound System -- Status: OK 0000
56-Radio -- Status: OK 0000
75-Telematics -- Status: Malfunction 0010
77-Telephone -- Status: OK 0000
-------------------------------------------------------------------------------
Address 01: Engine (CJA) Labels: 03L-906-022-CBE.clb
Part No SW: 03L 997 030 M HW: 03L 907 309 AA
Component: R4 2.0l TDI G000AG 9983
Revision: 12H16--- Serial number:
Coding: 0050078
Shop #: WSC 43585 002 1048576
VCID: 38292A989E59EBC766D-806C
2 Faults Found:
000135 - Fuel Rail/System Pressure
P0087 - 001 - Too Low - Intermittent
Freeze Frame:
Fault Status: 00100001
Fault Priority: 2
Fault Frequency: 1
Reset counter: 255
Mileage: 66097 km
Time Indication: 0
Date: 2019.01.31
Time: 01:02:06
Freeze Frame:
RPM: 1495 /min
Inj. Quantity: 45.0 mg/str
(no units): 5.0
Pressure: 1224.0 bar
Pressure: 840.0 bar
Temperature: 26.1°C
Tank Cont.: 47.6 l
000135 - Fuel Rail/System Pressure
P0087 - 004 - Too Low - Intermittent
Freeze Frame:
Fault Status: 00100100
Fault Priority: 2
Fault Frequency: 1
Reset counter: 255
Mileage: 66252 km
Time Indication: 0
Date: 2019.02.02
Time: 06:29:20
Freeze Frame:
RPM: 1656 /min
Inj. Quantity: 36.5 mg/str
(no units): 4.0
Pressure: 1368.0 bar
Pressure: 1072.0 bar
Temperature: 33.3°C
Tank Cont.: 36.4 l
Readiness: 0 0 0 0 0
Last edited: