View Single Post
Old April 13th, 2019, 01:47   #1
Crafter Jim
Newbie
 
Join Date: Apr 2019
Location: France
Default Crafter tdi wont rev up/excessive smoking

Thank you for welcomiong me to your group, i have a problem with my recently aquired 2008yr, crafter 2.5tdi 109, with 153k on the clock.
I bought the van cheap with this fault, being told the van had been plugged in to vag com and came back with 2 faults, egr and maf faults, no eml on in dash ,just flashing glow plug light. It starts and will drive but will not rev up and excessive grey/blue smoke smelling very fuelly. Purchased a egr delete kit and new bosch maf, fitted last night.Old maf was a little sooty but seen worse , the egr was carbonned up but once again seen worse. Runs the same, mate plug in his singing and dancing diagnostic pc, no faults ?
Spent all last might on pc researching and it may be the following, blocked DPF/Cat, loose turbo pipes or knackered injector/s. Will do leak off test today and check all pipes and hoses. Any ideas?
Crafter Jim is offline   Reply With Quote
 
Page generated in 0.06424 seconds with 8 queries
[Output: 14.67 Kb. compressed to 13.24 Kb. by saving 1.43 Kb. (9.74%)]