vegtech
Member
- Joined
- Jun 8, 2009
- Location
- New Hampshier
- TDI
- 99 jetta tdi, 03 golf, 05 jetta pd,05 toureg all on wvo
i have a brm engine here that will not start. the other day it started really hard. it cranked untill the battery ws alomst dead then it started. but would not rev up i had the owner unhook the battery, wait then hook it back up. that got him on the road he brought it straight to me. i ran veg com and found a bunch of codes and cleared them all test drove and it it ran ok but i new it was not right. check codes and found pd unit injector 1 and 4 implausible signal. clear it and they come back a few miles down the road. it had not had a fuel filter in it that i know of so i changed that and did some more driving it made a diff but still had the same codes keep coming back so i called it a day and went home to research the codes and found all about the T8 connector figuerd that was it so the next day i went to the shop and was going to do all of the test i had found on it but it would not and will not restart. i had started it 30 times the day before but now nothing. I have done all the fuel test and it is getting fuel and presure at the tandem pump. I was also told about the screen inside the tandem pump so i opened it up and cleaned that it was dirty but it did not make it run . I did DanG144 T8 test and found i only have .15v ish on pins 2,3,5,6 where it should be .55 and also the ohms to gound that should be >200K i am getting around 1.448M on pins 2,3,5,6 and 3.35K on pin 7 i have looked at the wire harness and found nothing wrong i have cleaned the grounds under the air box. I did notice that Dans specs are for a BEW engine and it says (may apply to BRM) does anyone know if this is the case or are the specs. differant? any help would be great. Yes this car is on WVO but it does not seem to be a fuel system problem at all but I'm sure some of the haters will tell me thats the problem. lol let me Know if you can help. If you want to call feel free 603-630-5408